2009 Ford Edge Transfer Case Leak

2007-2014 Ford Edge PTO PTU tansfer case replacement - YouTube. Remove the transfer case from the vehicle.

How To Check And Fill Transfer Case Fluid 11 19 Ford Explorer Youtube

Over time the transfer case output shaft seal can fail and when it does will display a few symptoms that will alert the driver that a problem with this system exists.

2009 ford edge transfer case leak. So that was what was causing the smell. You have to pull your transfer case to tell. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.

Dealership originally replaced seal on PTU 4 days mainly for seal but took it back on the next monday cause the leak returned and de dealership replaced PTU from previous leak issue. Jump to Latest Follow 1 - 7 of 7 Posts. There might be jerking.

Lower and at the same time slightly tilt the rear of the transfer case downward. The oil was basically dripping out of the transfer case and burning up on the exhaust manifold. The power take off unit transfer case developed a leak on the right hand side.

Your output seal on the tranny or input seal on your transfer case is bad. The transmission is one of the most important parts of the vehicle. If the leak gets worse on the trip and you loose to much fluid the transfer case can lock up and leave you stranded on the side of the road.

Move the transfer case rearward until the transfer case clears the output shaft. 2007-2014 Ford Edge PTO PTU tansfer case replacement. You will come into problems at some point.

Upon researching the unit which claims to have a lifetime fluid of gear-oil has a serious design flaw in which the unit is not properly cooled and the lifetime fluid breaks down due to heat causing the unit to fail. 3 weeks later PTU unit was replaced. When this fails and it will it will cost you 160000 more or less at a dealer.

I took it to the Ford dealership where they diagnosed that transmission was fine but the power transfer unit was leaking and the entire unit needed replacement. If it is just a seal leaking form the front or rear drive shaft the seal should be replaced before your trip just to make sure you have a safe trip. A forum community dedicated to Ford F-series owners and enthusiasts with a Power Stroke diesel engine.

Remove the remaining transfer case to transmission bolts. Ford will notify owners and dealers will replace the startstop accumulator. If the transmission fluid leaks that needs to be patched quickly.

And one thing we noticed was a fluid leak coming from the right transfer case seal directly onto the exhaust pipe which sits right underneath where the axle seal is located. Delayed shifts will cause acceleration problems. 15k noticed oil burning smell coming through the vents - Dealer replaced PTU unit.

They think there is TSB on it maybe a redesign case so they are checking will order the parts and then call me. Drop front and rear drive linesdiconnect transfer case shift linkage. Leak between tranny and transfer case.

Has the oil leak issue been resolved in the 2009 Ford Edge AWD. Noted below are a few of the common side effects of a damaged transfer case output shaft seal that should be. Its due to a very poor design on.

Some 2007-2010 Edge MKX 2008-2009 Taurus-X from the transaxle through the input hub of the Sable 2008-2010 Taurus 2009-2010 Flex and MKS PTU where the intermediate shaft seal is located. I cant seem to get answers fr. Remove the bolts to the transmission.

By nich Sun Feb 07 2010 102 am. A Factory well-known problem with the transmission on the 2009 model came to appear. A and 2010 MKT vehicles may experience a fluid leak red ATF leak indicates fluid from the transaxle is at the power transfer unit PTU right hand RH.

This is a pretty straight forward job. The Ford Edge transfer case recall is for North American 2015-18 Ford Edge models. If any of you out there drive an all-wheel-drive Ford Edge Flex or 500 or Lincoln MKS be aware these have a time-bomb transfer case issue.

No matter what you need for your Ford Edges transfer case from gaskets to control module we have the replacement parts to get the power to the wheels. What Owners Should Do. Put transfer case in neutral.

The leak drips onto the exhaust pipe creating smoke and an awful smell. Internal Oil Leak that could lead to external leak and compete damage of. Went to the dealer this morning to get it inspected they came back saying that my transfer case part of the AWD system is leaking via a vent tube.

Separate the transfer case from the transmission. Same thing happened again at 37K and Dealer said new and improved PTU unit was available ordered part. The gears may become stuck.

It could be the imput shaft seal on the transfer case. Found a nice oil spot in my normally very clean garage right under the Flex front. AWD Edge developed leak from passenger side output shaft from the Power Transfer Unit PTU similar to the x-fer case.

The bolt on either end face each other. There is a short commponent connecting the trans to the transfer case. Cost of repair 1800.

Ford Edge Transfer Case Leakage PTU unit AWD. This could result in a fire.

Pin On Ford Auto Repair Service In Pensacola Fl